Email Alert  RSS
70周年所庆专栏

CVD法制备铝化物涂层组织结构的温度依赖效应

展开
  • (1.西安交通大学金属材料强度国家重点实验室, 陕西 西安 710049;2.中国机械总院集团武汉材料保护研究所有限公司, 湖北 武汉 430030)
孟国辉(1991-),博士,助理教授,主要研究方向为热防护涂层,电话:18292876351,E-mail: mengguohui@ xjtu.edu.cn

收稿日期: 2023-04-02

  修回日期: 2023-05-12

  录用日期: 2023-06-13

  网络出版日期: 2023-09-15

基金资助

国家重点研发计划(2020YFB2010403)资助

Temperature-Dependent Effect of Microstructure of Aluminide Coating Prepared by CVD

Expand
  • (1.State Key Laboratory for Mechanical Behavior of Materials, Xi’an Jiaotong University, Xi’an 710049, China;2.Wuhan Research Institute of Materials Protection Co., Ltd.CAM, Wuhan 430030, China)

Received date: 2023-04-02

  Revised date: 2023-05-12

  Accepted date: 2023-06-13

  Online published: 2023-09-15

摘要

铝化物涂层制备技术由于非视线性沉积优势广泛应用于燃气轮机关键热端部件上,可在部件外表面以及内腔表面制备抗氧化耐腐蚀铝化物涂层。 涂层的组织结构是影响其服役性能的关键,然而如何调控铝化物涂层的组织结构从而获得理想性能的涂层是目前研究的难点问题。 针对这一问题,研究了关键制备参数温度对铝化物涂层组织结构的影响作用。 首先,采用化学气相沉积方法(CVD)在Mar-M247 镍基高温合金表面制备了不同沉积温度下的铝化物涂层。 然后,采用扫描电子显微镜(SEM)、X 射线衍射仪(XRD)以及能谱分析仪(EDS)分析了铝化物涂层的显微组织结构、物相组成以及合金元素在涂层中的分布情况。 结果表明,不同沉积温度下所得到的铝化物涂层均为双层结构,外层是富含Al 元素的β-NiAl 层,内层为富含拓扑密排相(TCP)的互扩散层;随着沉积温度的升高,β-NiAl 层与互扩散层的厚度逐渐增加,两者与温度之间具有正相关关系。 本研究揭示的温度参数对铝化物涂层组织结构的作用规律可为高性能CVD 法铝化物涂层的制备提供参考。

本文引用格式

齐浩雄, 吴勇, 刘梅军, 孟国辉, 孙清云, 陈同舟, 段海涛, 杨冠军 . CVD法制备铝化物涂层组织结构的温度依赖效应[J]. 材料保护, 2023 , 56(9) : 30 -38 . DOI: 10.16577/j.issn.1001-1560.2023.0209

Abstract

Owing to the advantages of non-line-of-sight deposition,the aluminide coating preparation technology is widely used on key hot-end components of gas turbines, and can prepare oxidation-resistant and corrosion-resistant aluminide coatings on the outer surface and inner cavity surface of the components.The microstructure of the coating is the key factor affecting its service performance,but how to adjust the microstructure of the aluminide coating to obtain a coating with ideal performance is a difficult problem in current research.Aiming at this problem, the effect of temperature, a key preparation parameter, on the microstructure of aluminide coatings was studied in this work.Firstly, aluminide coatings at different deposition temperatures were prepared on the surface of Mar-M247 nickel-based superalloy by chemical vapor deposition(CVD).Then, the microstructure, phase composition and distribution of alloying elements in the aluminide coating were analyzed by scanning electron microscope (SEM), X-ray diffractometer (XRD) and energy spectrum analyzer (EDS).Results showed that the aluminide coatings obtained at different deposition temperatures had a double-layer structure, the outer layer was a β-NiAl layer rich in Al, and the inner layer was an interdiffusion layer rich in topological close-packed phase (TCP).With the increase of deposition temperature,the thickness of β-NiAl layer and interdiffusion layer increased gradually, and there was a positive correlation between the two and temperature.Moreover, the effect of temperature parameters on the microstructure of aluminide coatings revealed in this study could provide a reference for the preparation of highperformance CVD aluminide coatings.

参考文献

[1] 叶 雄,谭 俊,宋 晧,等.航空发动机叶片叶尖涂层的研究进展[J].材料保护, 2018,51(2):87-94.YE X, TAN J, SONG H, et al.Study advances of blade tip coatings for aero-engine[J].Materials Protection, 2018,51(2):87-94.

[2] 张 磊,吴 勇,顿易章,等.采用CVD 法制备空心叶片内腔铝化物涂层[J].金属热处理, 2019,44(5):124-128.ZHANG L, WU Y, DUN Y Z, et al.Preparation of aluminide coating on hollow-blade inner-cavity by CVD method[J].Heat Treatment of Metals, 2019,44(5):124-128.

[3] 李家惠,刘梅军.防钛火金属/陶瓷阻隔层设计与制备方法[J].材料保护, 2021, 54(10):102-110.LI J H, LIU M J.Design and preparation methods of metallic/ceramic barrier layer for titanium -fire retardant[J].Materials Protection, 2021, 54(10):102-110.

[4] 任 鑫.几种高温防护涂层的高温氧化和热腐蚀行为研究[D].南京:南京理工大学, 2005.REN X.High-temperature oxidation and hot corrosion behavior of several high -temperature protective coatings[D].Nanjing: Nanjing University of Science and Technology,2005.

[5] 周永莉,鲁金涛,黄锦阳,等.粉末包埋渗铝与气氛渗铝对P92 钢650℃饱和蒸汽氧化行为的影响[J].中国表面工程, 2020,33(4):111-120.ZHOU Y L,LU J T,HUANG J Y,et al.Effects of pack cementation aluminizing and vapor aluminizing on oxidation behavior of P92 steel in saturated steam at 650 ℃[J].China Surface Engineering, 2020,33(4):111-120.

[6] 夏思瑶,吴 勇,张博闻,等.镍基高温合金上钯改性铝化物涂层的研究进展[J].材料保护, 2021,54(10):111-116.XIA S Y, WU Y, ZHANG B W, et al.Research progress of palladium -modified aluminide coating on nickel -based superalloy[J].Materials Protection, 2021,54(10):111-116.

[7] 李 微,黄 煌,黄伟颖,等.钢表面粉末包埋渗铝的表面状态及元素扩散机理研究进展[J].中国表面工程,2021,34(3):25-39.LI W, HUANG H, HUANG W Y, et al.Research progress on surface state and element diffusion mechanism of steel with surface coating prepared by pack aluminizing method[J].China Surface Engineering, 2021,34(3):25-39.

[8] 李广忠,王 昊,金 辉,等.渗铝G115 钢的制备及其在模拟煤炭超临界水气化中的腐蚀行为[J].材料保护,2021,54(12):30-35.LI G Z, WANG H, JIN H, et al.Preparation of aluminizing G115 steel and its corrosion behavior in simulation supercritical water gasification of coal[J].Materials Protection,2021,54(12):30-35.

[9] GOWARD G W.Progress in coatings for gas turbine airfoils[J].Surfaceand Coatings Technology, 1998, 108-109:73-79.

[10] 张博闻,吴 勇,杨 甫,等.CVD 法制备铝化物涂层装置沉积室内前驱体流场仿真设计研究[J].材料保护,2021,54(5):1-6.ZHANG B W, WU Y, YANG F, et al.The analogue design research of precursor gas flow field in the deposition chamber for aluminide coating device deposited by the CVD method[J].Materials Protection, 2021,54(5):1-6.

[11] 范凯平,吴 勇,杨 甫,等.镍基燃气轮机叶片改性铝化物渗层的研究进展[J].材料保护, 2014,47(6):57-61.FAN K P, WU Y, YANG F, et al.Research progress of modified aluminide coating on nickel - based gas turbine blades[J].Materials Protection, 2014,47(6):57-61.

[12] 王明静.镍基高温合金表面铬铝涂层的制备与抗高温腐蚀性能研究[D].西安:西安科技大学, 2011.WANG M J.Preparation and high temperature corrosion resistance of Cr-Al coating on the surface of Ni based superalloy[D].Xi’an: Xi’an University of Science and Technology, 2011.

[13] 程永鑫.镍基单晶高温合金中拓扑密堆相析出行为和变形机制研究[D].合肥:中国科学技术大学, 2021.CHENG Y X.Precipitation behavior and deformation mechanisms of topologically close-packed phases in Ni-based single crystal superalloys[D].Hefei: University of Science and Technology of China, 2021.

[14] 刘培生,梁开明,顾守仁.铝化物涂层高温氧化寿命的预测[J].清华大学学报, 2003,43(6):766-768.LIU P S, LIANG K M, GU S R.High-temperature oxidation lifetime prediction for aluminide coatings in air[J].Journal of Tsinghua University, 2003,43(6):766-768.

[15] 李建平,陆 峰,蔡 妍,等.空心叶片内腔化学气相沉积设备及抗氧化涂层研究[J].材料工程, 2005(10):38-41.LI J P, LU F, CAI Y, et al.Study of CVD equipment and protective coatings for the surface of internal cooling channels in turbine blades[J].Journal of Materials Engineering,2005(10):38-41.

[16] BESTOR M A, ALFANO J P, WEAVER M L.Influences of chromium and hafnium additions on the microstructures of β-nial coatings on superalloy substrates[J].Intermetallics,2011,19(11):1 693-1 704.

[17] 安 宁,袁晓飞,牛永吉,等.Mar-M247 铸造高温合金平衡析出相热力学计算与分析[J].航空材料学报, 2018,38(6):19-28.AN N, YUAN X F, NIU Y J, et al.Thermodynamic calculation and analysis of equilibrium precipitated phases in Mar-M247 superalloy[J].Journal of Aeronautical Materials, 2018,38(6):19-28.

[18] BIANCO R, RAPP R A.Pack cementation diffusion coatings[M].London: Chapman & Hall, 1996.

[19] SUN W P, LIN H J, HON M H.CVD aluminide nickel[J].Metallurgical Transactions A, 1986,17(2):215-220.

[20] EINSTEIN A.Investigations on the theory of the brownian movement[M].New York:Dover Publications Inc, 1956.

文章导航

/