Simulation Research on the Corrosion Behavior of X70 Pipeline Steel under Dynamic AC Interference

CAO Guofei, QIU Chunbin, ZHAO Dongye

doi:10.16577/j.issn.1001-1560.2024.0249

Materials Protection >

2024 , Vol. 57 >Issue 11: 53 - 61

DOI: https://doi.org/10.16577/j.issn.1001-1560.2024.0249

Simulation Research on the Corrosion Behavior of X70 Pipeline Steel under Dynamic AC Interference

Expand

(PipeChina West East Gas Pipeline Company，Shanghai 200000，China)

CAO Guofei (1985－)，Master，Senior Engineer，Research Focus: Corrosion and Protection of Pipes，Tel.:021－50958211，E-mail: 421781435＠qq.com

Received date: 2024-01-12

Revised date: 2024-07-29

Accepted date: 2024-07-30

Online published: 2024-12-23

Fold

Abstract

In order to provide reference for the anti-corrosion design of pipelines near electrified railways，the characteristics of AC dynamic interference parameters near pipelines of different railway types were studied on the basis of pipeline monitoring data.The corrosion behavior of buried X70 pipeline steel under dynamic AC interference in high-speed and ordinary railways was studied and analyzed through using a dynamic AC corrosion simulation test device under cathodic protection.Results showed that in a typical dynamic interference cycle，a higher dynamic AC interference current density resulted in a higher corrosion rate of X70 steel under the same cathodic protection potential.When the dynamic AC current density was higher than 100 A/m2，the corrosion rate was higher than 0.03 mm/a under any cathodic protection conditions.Under dynamic communication interference，as the level of cathodic protection increased，the corrosion rate presented a “saddle shaped”pattern，first decreasing and then increasing.Only when the AC current density was 30 A/m2 and the cathodic protection level was between－0.90 and－1.15 V (vs CSE)，the corrosion rate was less than 0.03 mm/a.Furthermore，even if the pipeline was in an effective cathodic protection state，corrosion would occur under dynamic communication interference.

Key words： X70 steel; cathodic protection; dynamic AC interference; corrosion rate; corrosion morphology; corrosion products

Cite this article

CAO Guofei, QIU Chunbin, ZHAO Dongye . Simulation Research on the Corrosion Behavior of X70 Pipeline Steel under Dynamic AC Interference[J]. Materials Protection, 2024 , 57(11) : 53 -61 . DOI: 10.16577/j.issn.1001-1560.2024.0249

Options

Outlines

模态框（Modal）标题

Abstract

Cite this article